接地端热传导对聚酰亚胺内带电的影响

摘要/Abstract

摘要： 提出局部接地和传热模式下介质深层充电的建模方法，选取常用的聚酰亚胺材料模拟空间高能带电粒子的辐照情况，研究了局部接地和传热情况下介质的深层充电特性。仿真结果表明：温度在183.15～363.15 K范围时，电位峰值受接地铜板直径和接地端温度的影响较大；温度在183.15～273.15 K范围时，场强峰值受接地铜板直径和接地端温度的影响较大；温度在273.15～363.15 K范围时，场强峰值受接地铜板直径和接地端温度的影响较小，但仍存在放电风险，场强峰值接近甚至超过106 V/m。仿真结果为星用热控材料的合理布局及太阳电池阵玻璃盖片的热防护和带电防护提供了参考。

Abstract: A modeling method of deep dielectric charging in local grounding and heat transfer mode is proposed. Commonly used polyimide materials are selected to simulate irradiation of high energy charged particles in space, and deep charging characteristics of dielectric in local grounding and heat transfer are investigated. Simulation results show that when the temperature ranges from 183.15 K to 363.15 K, the peak electric potential is influenced by the diameter and temperature of the grounding plate. When the temperature ranges from 183.15 K to 273.15 K, the peak field strength is largely influenced by the diameter and temperature of the grounding plate. When the temperature ranges from 273.15 K to 363.15 K, the peak field strength is less influenced by the diameter and temperature of the grounding plate, but there is still discharge risk, and the field strength peak is close to or even more than 106 V/m. Simulation results can provide a reference for the reasonable layout of the thermal control materials and thermal protection and charging protection of solar cell array glass cover sheet.

蒙志成，孙永卫，王松，原青云. 接地端热传导对聚酰亚胺内带电的影响[J]. 量子电子学报.

MENG Zhicheng, SUN Yongwei, WANG Song, YUAN Qingyun. Influence of ground heat conduction on inner charge of polyimide[J]. Chinese Journal of Quantum Electronics.

参考文献

[ ] Gao Bingrong, Hao Yongqiang, Jiao Weixin. A study on spacecraft internal charging with Monte Carlo method[J]. Chinese Journal of Space Science(空间科学学报), 2004, 24(4): 289-294(in Chinese). [ ] Ma Yali, Wang Li, Qin Xiaogang, et al. Application of the measurement techniques of space charge distribution in the internal dielectric charging analysis[J]. Vacuum and Cryogenics(真空与低温), 2007, 13(2): 120-124(in Chinese). [ ] Zhang Chunxia, Zhou Chunmei, Lin Jinyong. Experimental study of EMP coupling for electronic equipment[J]. Aerospace Control(航天控制), 2010, 28(5): 89-92(in Chinese). [ ] Li Shengtao, Li Guochang, Min Daomin, et al. Influence of radiation electron energy on deep dielectric charging characteristics of low density polyethylene[J]. Acta Physica Sinica(物理学报), 2013, 62(5): 59401-059401(in Chinese). [ ] Rodgers D J, Ryden K A, Wrenn G L, et al. Fitting of material parameters for DICTAT internal dielectric charging simulations using DICFIT[C]. Proceedings of International Symposium on Materials in a Space Environment, 2003, 540: 609-613. [ ] Rodgers D J, Cipriani F, Sorensen J, et al. Assessment of Jovian radiation belt electron-induced internal dielectric charging[C]. Radiation and Its Effects on Components and Systems (RADECS), 12th European Conference on IEEE, 2011: 511-515. [ ] Quan Ronghui, Han Jianwei, Zhang Zhenlong, et al. Experimental research and numerical simulation on deep charging for spacecraft dielectrics[J]. Chinese Journal of Space Science(空间科学学报), 2009, 29(6): 609-614(in Chinese). [ ] Li Yunze, Wei Chuanfeng, Yuan Lingshuang, et al. Fault modeling and simulation of satellite thermal control system[J]. Engineering Science(中国工程科学), 2005, 7(1): 38-40(in Chinese). [ ] Pan Zengfu. Study on key thermal control technology for micro-satellite[J]. Spacecraft Engineering(航天器工程), 2007, 16(2): 16-21(in Chinese). [ ] Zhu Liying, Qiao Ming, Liu Yenan, et al. Test and analysis on electrostatic discharge of high voltage and high power solar array for LEO spacecraft[J]. Spacecraft Engineering(航天器工程), 2015, 24(4): 65-70(in Chinese). [ ] Liu Zhiquan, Yang Shuli, Pu Hailing. Development and trend of space solar array technology[J]. Spacecraft Engineering(航天器工程), 2012, 21(6): 112-118(in Chinese). [ ] Chen Xi, Wang Xia, Wu Kai, et al. Temperature gradient effect on distortion of DC electrical field in polyethylene[J]. Journal of Xi'an Jiaotong University(西安交通大学学报), 2010, 44(4): 62-65(in Chinese). [ ] Qin Xiaogang, He Deyan, Wang Ji. Geant4-based calculation of electric field in deep dielectric charging[J]. Acta Physica Sinica(物理学报), 2009, 58(1): 684-689(in Chinese). [ ] Wang Song, Wu Zhancheng, Tang Xiaojin, et al. Study on temperature and electric field dependence of conductivity in polyimide[J]. Acta Physica Sinica(物理学报), 2016(2): 248-254(in Chinese). [ ] Huang Wengeng, Shen Hua, Liu Siqing, et al. Fluctuations of high-energy electron fluxes in earth's radiation belt and its applications for geomagnetic storm alert[J]. Chinese Journal of Space Science(空间科学学报), 2015, 35(1): 18-25(in Chinese). [ ] Ferreira G F L, Figueiredo M T D. Currents and charge profiles in electron beam irradiated samples under an applied voltage: exact numerical calculation and Sessler's conductivity approximation[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2003, 10(1):137-147. [ ] Wang Song, Wu Zhancheng, Tang Xiaojin, et al. Simulation of deep dielectric charging on satellite's exposed electric cable bundle[J]. Spacecraft Environment Engineering(航天器环境工程), 2015, 32(3): 268-272(in Chinese). [ ] Rodgers D J, Ryden K A, Wrenn G L, et al. Fitting of material parameters for DICTAT internal dielectric charging simulations using DICFIT[J]. Proceedings of International Symposium on Materials in A Space Environment, 2003, 540: 609 - 613.